Phone: 918-234-8665

Used Parts Washers

Washer Sales. Washer Buyers. Washer Service & Repair

Home/Brands/JENFAB/Jenfab Stainless Steel Pass Thru Parts Washer 26” Wide Belt by 24” Tall 3 Stage Wash, Rinse, Blow-Off

Jenfab Stainless Steel Pass Thru Parts Washer 26” Wide Belt by 24” Tall 3 Stage Wash, Rinse, Blow-Off

S/N 22200547

Delivered in January of 2019

Owners Comments: It’s run no more than (2) 8 hr shifts per week since, so nearly new.

Includes additional Oil Water Separator, Model RA-F-35

As Close to New as you can get, why wait for long 3-4 month delivery!

General Specifications:

Build System in One Piece

Washer is Stainless Steel On All Wetted Surfaces

Working Dimensions: 26” Wide x 24” Tall  (35” Load Height)

Process Zones:

  • Load Zone: 16”
  • Wash Zone: 36”
  • Drip Exit: 10”
  • Entry Zone Prior to Rinse: 10”
  • Rinse Zone: 36”
  • Drip Exit: 12”
  • Blow-Off Zone: 42”
  • Exit Zone: 16” 

Belt 1” x 1” Clinched Wire Stainless 1,000 lbs capacity evenly distributed”

Tank Capacity:

  • 200 GAL Wash    
  • 200 GAL Rinse   
  • Auto Water Fill/Low Water Shut Off on both tanks

Overall Dimensions: 166” W x 210” L x 100” T

Equipped with: 

  • Auto Water Fill/Low Water Shut Off on both tanks
  • Timer: 2 Channel Ch. 1 Runs Wash Heat, Ch. 2 Runs Rinse Heat
  • Emergency Stops on both sides of exit
  • Wash 5 H.P. Stainless Steel Gusher Pump 100 GPM @ 40 PSI
  • Rinse 5 H.P. Stainless Steel Gusher Pump 100 GPM @ 40 PSI
  • Filtration System 8×30 Stainless Steel (Wash/Rinse)
  • Electric Heat: 36 KW Rinse, 72 KW Wash
  • Steam Exhaust 2000 CFM Tubeaxial Fan (Wash/Rinse)
  • Blow-Off 8.5 H.P. Regenerative Blow Off ( Air Knives 2 above 1 below)
  • Side Removable Access Panels For Each Stage & Top Access Throughout Tunnel
  • Silicone Curtains Instead of Buna
  • Motorized Spray Bar Adjustment System to Manually Raise & Lower The Upper spray manifolds in the Wash, Rinse, & Air Knives in the Blow-Off
  • Throttle Valve on the Wash & Rinse, Stainless Steel
  • Drain Header: Galvanized drain header connecting wash & rinse drains together with brass ball valves flowing into a Pump-out box with electric centrifugal pump, ball valves manually controlled
  • Guide Rail:  Guide Rails Throughout Machine, Stainless Steel
  • Nozzles: Upgrade to SS ¼ Turn Quick Disconnect Nozzles
  • CamLocks: On wash & rinse spray manifolds, excluding top manifolds, Stainless Steel
  • Oil Coalescers: Per Each Tank (85 Gallons)
  • Clean Out Hatch Door On Wash Stainless
  • Includes additional Oil Water Separator, Model RA-F-35

Electrics:

  • Service Disconnect 200 AMP
  • Electric Box Nema 12 Industrial Controlled
  • 460 Volt 3 Phase, 175 FLA

 Buyer Loads Pheonix, AZ      

 

 

Leave a Comment